PURSUIT 2670 Cuddy Console El manual del propietario

2670 Cuddy Console12670 Cuddy ConsoleOWNER’S MANUAL921193February 2004, Revision AFISHING BOATS3901 St. Lucie Blvd.Ft. Pierce, Florida 34946

2670 Cuddy Console10THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console10014.3 RecommissioningDO NOT OPERATE THE BOAT UNLESS IT IS COMPLETELY ASSEMBLED. KEEP ALLFASTENERS TIGHT. KEEP ADJUSTMENTS A

2670 Cuddy Console101After Launching:• Carefully check all water systems and the engine bolts for leaks. Operate each system one at a timechecking fo

2670 Cuddy Console102THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console103GLOSSARY OF TERMSAft: In, near, or toward the stern of a boat.Aground: A boat stuck on the bottom.Amidships: In or toward the

2670 Cuddy Console104Bridge: The area from which a boat is steered and controlled.Bridge Deck: A deck forward and usually above the cockpit deck

2670 Cuddy Console105EPIRB: Emergency Position Indicating Radio Beacon. Operates as a part of a worldwide satellite distresssystem.Even Keel: When

2670 Cuddy Console106Helm: The steering and control area of a boat.Hull: The part of the boat from the deck down.Inboard: A boat with the engin

2670 Cuddy Console107Moored: A boat secured with cables, lines or anchors.Mooring: An anchor permanently embedded in the bottom of a harbor that is

2670 Cuddy Console108Rubrail: Railing (often rubber or hard plastic) that runs along the boat’s sheer to protect the hull when comingalongside do

2670 Cuddy Console109Swimming Ladder: Much the same as the boarding ladder except that it extends down into the water.Taffrail: Rail around the rear

2670 Cuddy Console11Registration and NumberingFederal law requires that all undocumented vessels equipped with propulsion machinery be registered in t

2670 Cuddy Console110

2670 Cuddy Console111Appendix B:MAINTENANCE SCHEDULE AND LOGMAINTENANCEEach UseWeeklyMonthlyEach SeasonYearlyAs NeededenilretawehtwoleblluhnaelCXlluht

2670 Cuddy Console112HoursDate DealerService/RepairsMAINTENANCE LOG

2670 Cuddy Console113HoursDate DealerService/RepairsMAINTENANCE LOG

2670 Cuddy Console114HoursDate DealerService/RepairsMAINTENANCE LOG

2670 Cuddy Console115HoursDate DealerService/RepairsMAINTENANCE LOG

2670 Cuddy Console116HoursDate DealerService/RepairsMAINTENANCE LOG

2670 Cuddy Console117Appendix C:BOATING ACCIDENT REPORTFORM APPROVEDOMB NO.211-0010DEPARTMENT OFTRANSPORTATIONU.S. COAST GUARDC.G. 1865 (REV. 1/88)The

2670 Cuddy Console118If more than 3 fatalities and/or injuries, attach additional form(s)WAS VICTIM?[ ] Swimmer[ ] Non SwimmerDATE OFBIRTHADDRES

2670 Cuddy Console119Appendix D:Float Plan1. Name of person reporting and telephone number.2. Description of boat.Type Color TrimRegistration No. Leng

2670 Cuddy Console12USCG specifications and regulations relating to performance, construction, or materials. The equipmentrequirements vary accor

2670 Cuddy Console120THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console121Appendix E:TROUBLESHOOTINGGUIDE• Steering system is low on fluid. Fill and bleed system.• Steering system has air in it. Fill a

2670 Cuddy Console122ENGINE PROBLEMSThe engine is running too hot.The engine alternator is not charging properly.The engine suddenly will not oper

2670 Cuddy Console123• The strainer on the intake scoop is clogged preventingthe water from getting to the pump. Put the boat inreverse to clean the

2670 Cuddy Console13TABLE OF CONTENTSChapter 1: Propulsion System1.1 General ...

2670 Cuddy Console14Chapter 5: Fresh Water System5.1 General ...

2670 Cuddy Console15Chapter 10: Interior Equipment10.1 Cabin and V-Berth...6110

2670 Cuddy Console16Chapter 13: Routine Maintenance13.1 General ...

2670 Cuddy Console17Chapter 1:PROPULSION SYSTEM1.1 GeneralThe Pursuit 2670 Cuddy Console is designed to be powered with twin 2-cycle or 4-cycle outboa

2670 Cuddy Console18DO NOT PAINT THE OUTBOARD MOTORS WITH ANTIFOULING PAINTS DESIGNED FORBOAT HULLS. MANY OF THESE PAINTS CAN CAUSE SEVERE DAMAGE

2670 Cuddy Console191.5 PropellersThe propellers convert the engine’s power into thrust. They come in a variety of styles, diameters and pitches.The

2670 Cuddy Console2THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console20Fuel GaugeThe fuel gauge indicates the amount of fuel in the fuel tanks. The fuel gauge switch, located on the helm,is used

2670 Cuddy Console21Chapter 2:HELM CONTROL SYSTEMS2.1 GeneralThe helm controls consist of three systems: the engine throttle and shift controls, the

2670 Cuddy Console22The neutral safety switches should be tested periodically to ensure that they are operating properly. To testthe neutral safe

2670 Cuddy Console232.5 Engine Stop SwitchWE STRONGLY RECOMMEND THAT THE LANYARD BE ATTACHED TO THE DRIVERWHENEVER THE ENGINES ARE RUNNING.Your Pursui

2670 Cuddy Console242.7 Trim TabsThe trim tabs are recessed into the hull on the transom. Switches are usedto control the trim tabs. The switche

2670 Cuddy Console25INSPECT AND MAINTAIN STEERING SYSTEM REGULARLY. DO NOT ATTEMPT CON-TROL ADJUSTMENTS UNLESS YOU ARE FAMILIAR WITH SERVICING CONTRO

2670 Cuddy Console26THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console27Chapter 3:FUEL SYSTEM3.1 GeneralThe fuel system used in Pursuit boats is designed to meet or exceed the requirements of the U.S.

2670 Cuddy Console28Fuel FillsA fuel fill deck plate is located on each gunwale and is marked “GAS.” Thefuel fill is opened by turning it count

2670 Cuddy Console29Fuel withdrawal lines are equipped with anti-siphon valves where the lines attach to the fuel tanks. Thesevalves prevent gasoline

2670 Cuddy Console3SAFETY INFORMATIONYour 2670 Cuddy Console Owner’s Manualhas been written to include a number of safety instructions toassure the s

2670 Cuddy Console30To fill the fuel tank at a marina, follow this procedure:1. Make sure all switches are in the “Off” position.2. Make sure the

2670 Cuddy Console313.4 Oil Tanks (2-Cycle Engines)The remote oil tanks are equipped with deck fills located in the splashwell area. Pursuitprovides,

2670 Cuddy Console32THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console33Chapter 4:ELECTRICAL SYSTEM4.1 GeneralYour Pursuit is equipped with a 12-volt DC electrical system and may be equipped with an o

2670 Cuddy Console344.3 DC Distribution SystemBattery Switches and TABS UnitThere are three “ON” - “OFF” battery switches located on the front o

2670 Cuddy Console35HornActivates the boat horn.Bilge PumpActivates the manual stern bilge pump which is installed in the rear center of the bilge. T

2670 Cuddy Console36COCKPIT SWITCH PANELSBaitwell This switch activates the baitwell light and circulating pump that supplies water to the baitwel

2670 Cuddy Console37should be lit whenever someone is occupying the cabin. If the breaker has tripped, it indicates that there isa problem with the c

2670 Cuddy Console38SWIMMING NEAR A BOAT OPERATING ON AC ELECTRICAL SYSTEM CAN LEAD TOSEVERE SHOCK AND DEATH. NEVER SWIM OR ALLOW SWIMMING WHEN A

2670 Cuddy Console39Reverse Polarity Light Test SwitchThere is a momentary switch located next to the reversed polarity light in the AC breaker panel.

2670 Cuddy Console4THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console404.6 Electrical System Maintenance12-VOLT DC ELECTRICAL SYSTEM MAINTENANCEAt least once a year, spray all exposed electrical co

2670 Cuddy Console41The entire AC circuitry, especially the shore power cord, should be seasonally tested for proper continuityby an experienced elect

2670 Cuddy Console42THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console43Chapter 5:FRESH WATER SYSTEM5.1 GeneralThe fresh water system consists of a potable water tank, distribution lines and a distribu

2670 Cuddy Console445.3 Fresh Water System MaintenanceInformation supplied with water system components, by the equipment manufacturers, is includ

2670 Cuddy Console45Chapter 6:RAW WATER SYSTEM6.1 GeneralIn the raw or sea water systems, all water pumps are supplied by hoses connected to ball val

2670 Cuddy Console46ALWAYS TURN THE RAW WATER PUMP SWITCH TO THE “OFF” POSITION WHENLEAVING THE BOAT UNATTENDED.DO NOT RUN THE HIGH PRESSURE PUMP

2670 Cuddy Console476.4 Raw Water System MaintenanceThe following items should be done routinely to help maintain your raw water system:• Check hoses,

2670 Cuddy Console48THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console49Chapter 7:DRAINAGE SYSTEMS7.1 GeneralAll water is drained by gravity to overboard thru-hull fittings located in the hull sides a

2670 Cuddy Console5BOAT INFORMATIONPlease fill out the following information section and leave it in your Pursuit2670 Cuddy Console Owner’s Manual.

2670 Cuddy Console507.4 Bilge DrainageThe bilge pumps are located in the stern bilge. All bilgepumps pump water out of thru-hulls located above t

2670 Cuddy Console517.5 Fishbox, Cooler and Storage Compartment DrainsThe fishbox below the cockpit floor is drained overboard by a macerator pump-out

2670 Cuddy Console52• Operate the thru-hull valves once a month and service as required.ALL DRAINS AND PUMPS MUST BE PROPERLY WINTERIZED BEFORE WI

2670 Cuddy Console53Chapter 8:VENTILATION SYSTEM8.1 Cabin VentilationVentilation to the cabin area is provided by a deck hatch.Deck HatchThe deck hatc

2670 Cuddy Console54THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console55Chapter 9:EXTERIOR EQUIPMENT9.1 DeckRails and Deck HardwareThe rail system and hardware fittings have been selected and installe

2670 Cuddy Console56Windlass (Optional)The optional windlass is mounted to the deck near the rear of the pulpit above the rope locker. The anchor

2670 Cuddy Console579.2 HullSwim PlatformYour Pursuit is equipped with an integral swim platform and engine mounting system located in the stern ofth

2670 Cuddy Console58Stern Bait Rigging StationThe stern bait rigging station is equipped with a transom door, sink, livewell, cutting board and ri

2670 Cuddy Console59HelmThe helm and engine controls are located on an opening helm station.The helm station is hinged at the bottom and opens to prov

2670 Cuddy Console6THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console60The warranty for the T-top will be void if the top is modified in any way or heavy accessories like life rafts,or electronics

2670 Cuddy Console61Chapter 10:INTERIOR EQUIPMENT10.1 Cabin and V-BerthThe cabin and V-berth are accessed through a door hatch and bi-fold door. The

2670 Cuddy Console62THE MACERATOR DISCHARGE PUMP CAN ONLY BE RUN DRY FOR A FEW OF SEC-ONDS. ALLOWING THE MACERATOR PUMP TO RUN AFTER THE HOLDING

2670 Cuddy Console63Chapter 11:SAFETY EQUIPMENT11.1 GeneralYour boat and outboard engines have been equipped with safety equipment designed to enhan

2670 Cuddy Console6411.3 Neutral Safety SwitchEvery control system has a neutral safety switch incorporated into it. This device prohibits the en

2670 Cuddy Console65The carbon monoxide detector warns the occupants of dangerous accumulation ofcarbon monoxide gas. It is automatically activated w

2670 Cuddy Console66CO POISONING PRODUCES FLU-LIKE SYMPTOMS: WATERY AND ITCHY EYES, HEAD-ACHES AND FATIGUE. YOU CAN’T SEE IT AND YOU CAN’T SMELL

2670 Cuddy Console67Many manufacturers of carbon monoxide detectors offer a testing and recertification program. Werecommend that you contact the man

2670 Cuddy Console68plus one throwable device (Type IV).Visual Distress Signals:All Pursuit boats used on coastal waters, the Great Lakes, territo

2670 Cuddy Console69Navigation Lights:Recreational boats are required to display navigation lights between sunset and sunrise and other periods ofredu

2670 Cuddy Console7CERTIFICATIONS & SPECIFICATIONS(For Export Only)Manufacturer:NameAddressZip Code:Identification Numbers:Hull Identification Num

2670 Cuddy Console70GASOLINE CAN EXPLODE. IN THE EVENT OF A FUEL COMPARTMENT OR BILGE FIRE,YOU MUST MAKE THE DIFFICULT DECISION TO FIGHT THE FIRE

2670 Cuddy Console71Chapter 12:OPERATION12.1 GeneralBefore you start the engines on your Pursuit, you should have become familiar with the various c

2670 Cuddy Console72DECKS ARE SLIPPERY WHEN WET. WEAR PROPER FOOTWEAR AND USE EXTREMECAUTION ON WET SURFACES.12.2 Rules of the RoadAs in driving

2670 Cuddy Console73Overtaking SituationsWhen one motor boat is overtaking another motor boat,the boat that is being passed has the right of way. The

2670 Cuddy Console74THERE MUST BE AT LEAST ONE PERSONAL FLOTATION DEVICE ON BOARD FOR EV-ERY PERSON ON BOARD AND ONE THROW-OUT FLOTATION DEVICE.

2670 Cuddy Console75• Be sure the emergency stop lanyard is attached to the operator and the stop switch.VAPORIZING LIQUID EXTINGUISHERS GIVE OFF TOXI

2670 Cuddy Console76• Avoid sea conditions that are beyond the skill and experience of you and your crew.MAKE SURE ONE OTHER PERSON ON THE BOAT IS

2670 Cuddy Console77• Check the bilge area for debris and excess water.• Fill the fuel tanks to near full to reduce condensation. Allow enough room i

2670 Cuddy Console78• Be careful when using the trim tabs from the tower. The reaction of the trim tabs will be exaggeratedin the tower. Use sma

2670 Cuddy Console79Dock lines are generally twisted or braided nylon. Nylon is strong and stretches to absorb shock. It also hasa long life and is

2670 Cuddy Console8THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console80Leaving a MooringStart the engines and let them warm up for several minutes before releasing the mooring line. The boat willa

2670 Cuddy Console81proper operation. Plug all leaks or make the necessary repairs to the control systems before proceeding slowlyand carefully to po

2670 Cuddy Console82If the boat becomes swamped and capsizes, you and your passengers should stay with the boat as long as youcan. It is much eas

2670 Cuddy Console83 • Make sure the trailer bunks and rollers properly support the hull and do not put pressure on the liftingstrakes. The rollers a

2670 Cuddy Console8412.14 Man OverboardIf someone falls overboard, you must be prepared to react quickly, particularly when you are offshore. Th

2670 Cuddy Console85NOTICEBE SURE THAT THE SKIER IS WEARING A PROPER LIFE JACKET. A WATER SKIERIS CONSIDERED ON BOARD THE BOAT AND A COAST GUARD APPR

2670 Cuddy Console86THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console87Chapter 13:ROUTINE MAINTENANCE13.1 GeneralBEFORE USING A CLEANING PRODUCT, REFER TO THE PRODUCT DIRECTIONS ANDSPECIFICATIONS.IF UR

2670 Cuddy Console88Do not allow the hull antifouling paint to contact the outboard motor. Most antifouling paints designed for hullbottoms conta

2670 Cuddy Console89USE EXTREME CARE WHEN WALKING ON WET GELCOAT SURFACES AS THEY ARESLIPPERY.Stainless Steel HardwareWhen using the boat in saltwater

2670 Cuddy Console9Warranty and Warranty Registration CardsThe Pursuit Limited Warranty Statement is included with your boat. It has been written to

2670 Cuddy Console90YOU SHOULD CONTACT PURSUIT CUSTOMER RELATIONS BEFORE MAKING ANYMODIFICATIONS TO ALUMINUM FABRICATIONS. UNAUTHORIZED MODIFICAT

2670 Cuddy Console9113.3 Upholstery, Canvas and EnclosuresVinyl UpholsteryThe vinyl upholstery used on the exterior seats and bolsters, and for the h

2670 Cuddy Console92Snaps should be lubricated periodically with petroleum jelly or silicone grease. Zippers should be lubricatedwith silicone sp

2670 Cuddy Console9313.6 Drainage SystemIt is essential that the following items be done periodically to maintain proper drainage of your boat:• Clea

2670 Cuddy Console94THIS PAGE WAS LEFT BLANKINTENTIONALLY

2670 Cuddy Console95Chapter 14:SEASONAL MAINTENANCE14.1 Storage and Lay-upBefore Hauling:• Pump out the head. Flush the holding tank using clean soa

2670 Cuddy Console96BOATS CAN BE DAMAGED FROM IMPROPER LIFTING AND ROUGH HANDLING WHENBEING TRANSPORTED BY LIFT TRUCKS. CARE AND PROPER HANDLING

2670 Cuddy Console97Preparing The Boat For Storage:• Remove the bilge drain plug(s), if installed.• Thoroughly wash the fiberglass exterior, especiall

2670 Cuddy Console98The shower/cabin drain sump system must be properly winterized. Clean debris from the drain and sump andflush for several min

2670 Cuddy Console99ALWAYS MAKE SURE THE LEG DRAIN HOLES ARE CLEAR WHEN THE BOAT IS LAIDUP FOR THE WINTER. WATER TRAPPED INSIDE THE HARDTOP, TOWER O